I guess we started raising pigs about thirty years ago. I figured I could raise two pigs, sell one to pay for the cost of pigs and feed, and butcher the other one.
At first I started doing it the same way I had always seen it done. I fenced in a pretty good size hog lot out of woven wire and built a wooden pig house so they could get out of the weather. We would feed the pigs wheat bran, corn chops, garden and table scraps and lots of skim milk from our cow. When the pigs reached around 250 lbs I would sell one and get set up for butchering. I used the same method that has been done in the Ozarks for years. I learned it from watching my neighbor, Lonnie Lee butcher his hogs. We built a fire under a 55-gallon barrel full of water, and set up a pulley and rope system to raise the hog and lower it into the water. When the water was almost to a boil, I would shoot the hog between the eyes with a .22 rifle and quickly put a chain loop around it’s leg, pull it off the ground with my truck and sever the aorta with a butcher knife to get a good bleed. Then we would dip the whole hog into the barrel to cause the hair to slip, lay the hog on a home-made table, and scrape all the hair off with knives. When the hair was off, I would hang it, remove the viscera and internal organs, saw the carcass in half from tail to shoulders, and leave it hanging overnight to chill. I always try to butcher on a night when it will freeze. Not only is it important to cool the meat quickly, it is much easier to cut up meat when it is partially frozen.
For several years we tried the traditional method of preserving most of our meat through salting and smoking. This involves injecting the meat with brine, smothering the meat with salt, then after a time, smoking the heck out of it. You wind up with hams and shoulders that will keep without being frozen, but meat that is impossible to eat without soaking in water to remove some of the salt. It didn’t take too many years of this to figure out that a freezer would be a good thing. We bought a used freezer and paid a neighbor to keep it at her house (she had electricity). We continued to scald and scrape our hogs for a few more years until I figured out that the only reason to keep the skin on the hog was as a way of preserving the meat. Then we started skinning rather than scraping. No more smoky fires and dangerous scalding water. With a sharp skinning knife two of us can snatch the hide off a hog in about half an hour.
It only took a few years, though, to see that keeping hogs in a pen is an environmental disaster. I could see that they were wearing a hole in the ground from their constant rooting and wallowing. Not only that, but it was very expensive to buy feed, which of course they needed every day. That is when I discovered a new method of raising hogs. Now when we buy a little feeder pig we put it in a temporary pen in the same pasture with whatever calves I have on hand at the time. The calves are usually fascinated by the pig and spend a lot of time communing with it through the fence. It only takes a few days for the animals to bond—then I can release the pig and it spends the rest of it’s happy life roaming the farm with it’s bovine pals, grazing on grass and finding acorns and all sorts of goodies in the woods. Even though it can fit under the barbed-wire fence that is the boundary of our farm, the pig will NEVER get out of sight of the calves, so there is no danger of it finding it’s way to our nearest neighbor, a half-mile away.
Since I have been teaching guitar and fiddle at the local school one day a week, I haven’t had to buy ANY feed. One day’s lunch tray scrapings from 130 students is enough to feed a pasture-raised pig for a week! Now when I see the crater down in the woods that marks the spot where the hog pen used to be I just shake my head. We live and learn…………….from my website/blog bearpenfarm.net
Hi Boone; You have about a 15-20 year head start on me for pig raising. I use a rotational pen system to minimize land impact (works rather well) But your method of letting them hang with the calves is VERY interesting ! Currently we do not have cows but it has been discussed... Of course every fence on the place other than the pig pens, is in sorry shape. This could take a few years to implement but I really like the idea of letting the pigs have whole field access... and BUYING less grain for them... EDIT; Do you do this with only one piggy or several ? Thanks for sharing.
Good observation and I love the learning curve you went through.
We use our hogs as bulldozers letting them do a complete "mess things up" phase on land that we have decided to use for other plantings that what is there now, they do a great job of complete and total destruction in less than a year.
We also have pastures for them to rotate through so they don't just hang in one pen unless we are using them as bulldozers.
Our AGH are pasture hogs, they prefer to eat grasses and shrubs so we only supplement their food with feed or grocery scrap foods (we get out of date, past saleable produce, no meats).
We love visitors, that's why we live in a secluded cabin deep in the woods. "Buzzard's Roost (Asnikiye Heca) Farm." Promoting permaculture to save our planet. you can call me Dr. Redhawk